/Products/effect of residence time on the flotation of copper

effect of residence time on the flotation of copper

REDESIGN OF INDUSTRIAL COLUMN FLOTATION CIRCUITS

Figure 7. Effect of residence time on recovery for different feed solids contents copper, lead, zinc, and silver is recovered in the froth of flotation machines. As the grade Conditioning time in a flotation circuit may range from seconds to minutes.

get price

The effect of froth residence time on the kinetics of

Jul 01, 1998 This ratio, termed the froth residence time, has been proposed by certain flotation cell manufacturers as an effective method of accounting for the effect of the froth phase during flotation cell scale-up. However, at deep froth depths, or large values of froth residence time, the correlation between the data obtained from the 250 litre cell

get price

(PDF) Modeling and Analysis of Residence Time

Copper flotation can be also more complicated if flotation feed comes from an elevated-pyritic copper ore. In this investigation, the effect of two different ore types (high pyritic and low

get price

Specific Effects Of Slurry Concentration, Time And

Dec 26, 2019 Effect Of Flotation Time On Froth Flotation. Froth flotation time refers to the residence time of pulp in the flotation cell. The optimum flotation time for different ores is determined by conducting a froth flotation test. When the content of floated minerals is low, the floatability is good, the pulp concentration is low, the ore feeding size

get price

Analysis of the Effects of Grind Size on Production of

and residence time of the process to analyzing the effects that grind size of the ore can have on copper concentrate production during flotation process. Therefore this research was more focused on determining whether the size distribution of the ore after comminution would cause significant impact

get price

The effect of froth residence time on the kinetics of

Jul 01, 1998 This ratio, termed the froth residence time, has been proposed by certain flotation cell manufacturers as an effective method of accounting for the effect of the froth phase during flotation cell scale-up. However, at deep froth depths, or large values of froth residence time, the correlation between the data obtained from the 250 litre cell

get price

REDESIGN OF INDUSTRIAL COLUMN FLOTATION CIRCUITS

Figure 7. Effect of residence time on recovery for different feed solids contents copper, lead, zinc, and silver is recovered in the froth of flotation machines. As the grade Conditioning time in a flotation circuit may range from seconds to minutes.

get price

Water quality effects on flotation: Impacts and control of

Aug 15, 2018 Aug 15, 2018 With reduced residence time, lack of UV light and low temperatures in the dark and cold winter months to aid decomposition, more reagents and unsettled tailings are recycled back into the process with the water, which affects the flotation circuit performance. Fig. 3 shows a typical copper flotation performance varying in winter with

get price

The Effect of Oxidation on the Flotation Behaviour of

residence time in the flotation head tank, prior to any reagent addition. This flotation behaviour has been subsequently confrrmed without using any specific reagent. The objective of this paper is to discuss the results of the latter study in comparison with the usual flotation behaviour observed in plant practice as well as in laboratory studies.

get price

Increased liberation and flotation performance of bulk

Within a 2-minute residence time inside the Ro-Star mill, an improved liberation degree of the copper bearing minerals has been observed. As a consequence, enhanced copper recovery and selectivity against pyrite was noted. It has been found, that in order to guarantee efficient flotation of the resulting

get price

Analysis of the Effects of Grind Size on Production of

and residence time of the process to analyzing the effects that grind size of the ore can have on copper concentrate production during flotation process. Therefore this research was more focused on determining whether the size distribution of the ore after comminution would cause significant impact

get price

Review, Evolution and Optimization of the Kansanshi Mixed

The effect of the complex mineralogy on the flotation performance is depicted. Initially, ore treated came modifying configuration to increase the residence time and the number of sulphidisation The traditional method applied for the flotation of copper oxide or mixed ores is sulphidisation, which

get price

Flotation data for the design of process plants Part 2

sequential flotation circuit versus Cadia s simple copper gold flotation circuit. The common Keywords: Locked cycle tests, Residence time, Finely disseminated, Flotation circuit design, Hellyer Project, Cadia Project and the deleterious effects of recirculating loads. It was

get price

Froth mean residence time measurement in industrial

The froth mean residence times were evaluated from direct measurements of liquid and solid time responses in the froth of self-aerated copper flotation cells of 130 m 3 (Yianatos et al., 2008b

get price

Kinetics and Recovery of Xanthate-Copper Compounds by Ion

Residence time distribution The residence time distribution (RTD) was measured by the electrical conductivity method using an electrical conductiv-ity flow cell with graphite electrodes [16, 17]. We used 0.5 L of saturated solution of potassium chloride as a tracer; it was injected into the flotation cell and the electrical conductivity -1

get price

Use of residence-time distribution techniques to analyze

Dec 15, 1999 Residence-time distribution techniques are useful tools in the analysis, characterization and modeling of the performance of processing equipment and circuits. This paper presents the results of both conventional and more-sophisticated residence-time distribution techniques for industrial copper-flotation-circuit data. While conventional techniques provide a description that is sufficient for

get price

AN INVESTIGATION OF THE GAS DISPERSION PROPERTIES OF

effect on bubble size, although the degree of impact strongly depended on the agitation Figure 3.11 Material recovery as a function of theoretical liquid residence times and Figure 3.20 Copper grade in the concentrate stream as a function of water recovery and

get price

Separation efficiency improvement of a low grade copper

The copper flotation circuits upgrade copper content by a time which can have a negative effect on valuable mineral recovery. flotation circuit diagnostics and calculated residence times of each flotation bank are shown for both trains in the table below.

get price

(PDF) Modeling and Analysis of Residence Time Distribution

Copper flotation can be also more complicated if flotation feed comes from an elevated-pyritic copper ore. In this investigation, the effect of two different ore types (high pyritic and low

get price

Use of residence-time distribution techniques to analyze

Dec 15, 1999 Residence-time distribution techniques are useful tools in the analysis, characterization and modeling of the performance of processing equipment and circuits. This paper presents the results of both conventional and more-sophisticated residence-time distribution techniques for industrial copper-flotation-circuit data. While conventional techniques provide a description that is sufficient for

get price

Kinetics and Recovery of Xanthate-Copper Compounds by Ion

Residence time distribution The residence time distribution (RTD) was measured by the electrical conductivity method using an electrical conductiv-ity flow cell with graphite electrodes [16, 17]. We used 0.5 L of saturated solution of potassium chloride as a tracer; it was injected into the flotation cell and the electrical conductivity -1

get price

(PDF) Analysis of the Effects of Grind Size on.PDF Bupe

The total residence time in flotation was seven minutes. The overflowing froth of minerals was the concentrate collected. Recoveries of mineral values and grade increase as the The effect of grind time on particle size can be observed in grind gets finer. R. R. (1998), The Influence of Frother Structure on Industrial Copper Flotation

get price

Review, Evolution and Optimization of the Kansanshi Mixed

The effect of the complex mineralogy on the flotation performance is depicted. Initially, ore treated came modifying configuration to increase the residence time and the number of sulphidisation The traditional method applied for the flotation of copper oxide or mixed ores is sulphidisation, which

get price

Effect of Desliming on Flotation Response of Kansanshi

The Kansanshi mixed copper sulfide-oxide ore contains significant proportions of fine material manifesting in a variety of processing challenges. This paper presents the work which was carried out to evaluate the efficacy of desliming in improving the flotation response of the ore. Two modes of desliming were investigated, namely; sieving and elutriation after which the deslimed material was

get price

Flotation: The Past, Present and Future of Mineral

E&MJ explores the sustainability of a time-honored beneficiation technique . By Carly Leonida, European Editor. As we look to the future, the mining industry faces a myriad of challenges. While demand for metals like copper, cobalt, lithium and iron ore is projected to reach record highs by 2050, ore grades are decreasing, orebodies are becoming more complex, and fewer tier 1 deposits are

get price

The Application of High Intensity Flotation Technology at

960 second laboratory scale conventional flotation on the same feed material. The apparent improvement in flotation kinetics is attributed to the novel high intensity aeration system, which provides efficient bubble-particle contact thereby shortening the residence time

get price

Flotation Developments & Best Practice International Mining

Nov 04, 2013 Flotation Developments & Best Practice. Posted by Matrix on 4th November 2013. Prof Graeme Jameson is a nominee in the International Mining Technology Hall of Fame and his Jameson cell, marketed by Xstrata Technology, offers, among other advantages, high production in a small footprint and high concentrate grades.

get price

Sampling from large flotation cells LICENTIATE T H E SIS

flotation cells over time. Figure 1. Flotation cell size development throughout the years (Outotec, 2012) When looking forward, in a Boliden perspective, with regard to constructing new concentrator plants, there is a need to know how to implement the most low cost flotation

get price

Coarse PartiCle Flotation

COARSE PARTICLE FLOTATION OF LOW-GRADE GOLD ORE WITH THE HYDROFLOAT™ TECHNOLOGY n d A 6 A 5-0 m A 0-u T e n c s e y l F a es-d t r -. f l h d h o e f t w h i i t-s. –. S l RECOVERY OF VALUES FROM A PORPHYRY COPPER TAILINGS STREAM T-Y a h d A 5-0 0-g g s 6 (4 3-u T d-t o h D t t t g s e t-t a n r/ s t-s 1 e t e e t-h t-t t-n ircuit d ry

get price

(PDF) Kinetics and Recovery of Xanthate-Copper Compounds

In a system that presents perfect mixing with cell’s side. The fraction of gas holdup in its simplest form (air a residence time (t), the flotation rate constant [17] is given by system-water- surfactant) is given, under these conditions, by equation (6). equation (4), where DH is

get price

S olution str ategies to the stochastic design of miner al

two-stage stochastic problem applied to a copper flotation circuit. The paper begins by introducing a stochastic optimization problem whose aim is to find the best configuration of superstructure, equipment design and operational conditions, such as residence time and stream flows. Variability is considered in the copper price and ore grade.

get price

Innovative Methodology for Sulfur Release from Copper

Effect of Residence Time Figure 9 shows the effect of residence time on sulfur release rate and residual S content. From Figure 9,by increasing the duration time from 20 min to 60 min, the sulfur release rate and the residual S content were observed from

get price

Concentrator Process Development Phase IV Flotation Bench

Figure 14: Copper and Gold Recovery to Concentrate for Rougher Scoping Flotation Tests..32 Figure 15: Effect of Zinc Depressant Dosage on Flotation Kinetics for Proposed Reagent Scheme.....33 Figure 16: Effect of pH and Aero 5100 Promoter Dosage on Flotation Kinetics for Alternative Reagent

get price